Ford Archives - Page 3 of 6 - Built To Last Automotive Service

2013 Ford F-150
Mileage
74,146
Service Date
4/13/2021
Services Performed
FRONT BRAKE PADS ___10 MM_____REMAIN REAR BRAKE PADS ____8 MM____ REMAIN FRONT ROTORS __GLAZED___ REAR ROTORS ___GLAZED___ CALIPERS FRONT __OK___ REAR __OK___ BRAKE FLUID CONDITION ___GOOD____
REMOVES CONTAMINATED FLUID FROM THE ENTIRE HYDRAULIC SYSTEM. REPLACE FLUID WITH BG BRAKE FLUID.
REPLACE THE FRONT BRAKE CALIPERS
REPLACE THE PASSENGER FRONT WINDOW REGULATOR
RESURFACE THE FRONT AND REAR BRAKE ROTORS AND SCUFF PADS
UPON INSPECTION FOUND THAT THE FRONT AND REAR BRAKE PADS LOOK NEW, FRONT AND REAR BRAKE ROTORS ARE GLAZED, ADVISED THE CUSTOMER THAT WE CAN RESURFACED THE FRONT AND REAR BRAKE ROTORS, SCUFF UP THE FRONT AND REAR BRAKE PADS AND THEN RETEST, UPON GAINING ACCESS TO THE RIGHT FRONT BRAKE ROTOR TO RESURFACE FOUND THAT THE RIGHT FRONT BRAKE CALIPER IS SEIZED, WILL NEED TO REPLACE BOTH FRONT BRAKE CALIPERS AND FLUSH THE SYSTEM, RESURFACED THE FRONT AND REAR BRAKE ROTORS, SCUFFED THE FRONT AND REAR BRAKE PADS, REPLACED THE FRONT BRAKE CALIPERS AND PERFORMED BRAKE SYSTEM FLUSH, TEST DROVE AND REINSPECTED, OK AT THIS TIME
UPON INSPECTION FOUND THAT THE WINDOW REGULATOR HAS FAILED, GAINED ACCESS TO THE FAILED WINDOW REGULATOR, REMOVED AND INSTALLED NEW WINDOW REGULATOR AND RETEST, OK AT THIS TIME
KEVIN D. gave our service a 5 star review on 4/29/2021
2019 Ford F-250 Super Duty
Mileage
11,343
Service Date
1/11/2021
Services Performed
Lubricate and check chassis. Change oil and oil filter. Check air filter and breather filter. Check and top-off all fluid levels and tire pressures. Perform basic safety inspection. Road test vehicle. RESET MAINTENANCE LIGHT.
REMOVE ALL TIRES, ROTATE FRONT TO REAR, CHECK AIR PRESSURE AND TORQUE LUG NUTS. RESET TIRE SENSORS IF EQUIPPED.
STEVE J. gave our service a 5 star review on 1/29/2021
2006 Ford Pickup
Mileage
255,064
Service Date
10/1/2020
Services Performed
UPON INSPECTION TEST DROVE VEHICLE AND WAS ABLE TO FEEL TRUCKING LACKING IN POWER, VEHICLE DID NOT DIE WHILE DRIVING. INSPECTED BATTERY AND CABLES FOUND THAT BOTH BATTERY CABLES WERE LOOSE AND DID NOT HAVE GOOD CONTACT OR GROUND. TIGHTENED BOTH BATTERY CABLES DOWN, GOOD. THE CEL IS ON, SCANNED VEHICLE FOR CODES AND FOUND CODES FOR GLOW PLUGS, THIS COULD CAUSE THE LACK OF POWER AND SMOKE. RECOMMEND REPLACING GLOW PLUGS AND RETEST. ALSO NOTICE FAN CLUTCH NOT WORKING PROPERLY, RECOMMEND REPLACE FAN CLUTCH.
TY H. gave our service a 5 star review on 10/8/2020
2007 Ford Pickup
Mileage
159,699
Service Date
7/27/2020
Services Performed
REPLACE TRANSMISSION ASSEMBLY
REPLACE TRANSMISSION OIL COOLER AND FLUSH LINES
TEST DROVE VEHICLE AND CAN FEEL THE TRANSMISSION SLIPPING BETWEEN GEARS. SCANNED VEHICLE FOR CODES AND FOUND CODES THAT SEEMS TO BE FALSE BECAUSE THE TRANSMISSION IS CONFUSED. CHECKED FLUID LEVEL AND FOUND IT TO BE 1 GALLON LOW. ADDED FLUID TO PROPER LEVEL BUT NO CHANGE OCCURRED WHILE DRIVING. REMOVED THE TRANSMISSION PAN TO INSPECT, FOUND EXCESSIVE METAL DEBRIS IN PAN. RECOMMEND REPLACE OR REBUILD TRANSMISSION.
GARY J. gave our service a 5 star review on 8/3/2020
2015 Ford F-350 Super Duty
Mileage
83,482
Service Date
5/21/2020
Services Performed
Lubricate and check chassis. Change oil and oil filter. Check air filter and breather filter. Check and top-off all fluid levels and tire pressures. Perform basic safety inspection. Road test vehicle.
UPON INSPECTION TESTED THE 4X4 OPERATION, FOUND THAT WHEN THE FRONT HUBS ARE MANUALLY LOCKED IN THE 4X4 WILL ENGAGE, AUTO HUBS ARE NOT LOCKING IN, PERFORMED PINPOINT TESTING ON THE WIRING TO SHIFT ACTUATOR, GOOD, PERFORMED VACUUM TEST ON THE SYSTEM AND FOUND A VACUUM LEAK, WILL NEED TO DISASSEMBLE THE FRONT END TO FURTHER DIAG
UPON INSPECTION VERIFIED THE CUSTOMERS CONCERN, PRESSURE TESTED THE SYSTEM AND SAW COOLANT LEAKING FROM A HOSE BELOW THE THERMOSTAT HOUSING, GAINED ACCESS TO FAILED HOSE AND INSTALLED NEW HOSE, FILLED AND TOPPED OFF THE COOLANT TO THE PROPER FLUID LEVEL, RETEST THE SYSTEM, NO FURTHER COOLANT LEAK DETECTED AT THIS TIME
ROBERT F. gave our service a 5 star review on 5/21/2020
2006 Ford Pickup
Mileage
310,197
Service Date
1/8/2020
Services Performed
INSTALLED NEW ENGINE AIR FILTER
REPLACE THE #4 FUEL INJECTOR
REPLACE THE FICM
REPLACE THE FUEL FILTERS
REPLACE THE FUEL INJECTOR HARNESS
REPLACE THE GLOW PLUG CONTROLER
UPON INSPECTION SCANNED THE VEHICLE FOR TROUBLE CODES, FOUND TROUBLE CODES: P0611 Fuel Injector Control Module Performance P1378 Fuel Injection Control Module Circuit Low Voltage P0261 Cylinder 1 Injector Circuit Low P0270 Cylinder 4 Injector Circuit Low P0674 Cylinder 4 Glow Plug Circuit Fault UPON INSPECTION THE FUEL INJECTOR HARNESS, FOUND THAT THE PLASTIC PORTION OF THE HARNESS IS VERY BRITTLE AND FALLING APART, REPLACED THE FUEL INJECTION WIRING HARNESS AND RETEST, STILL HAVE A NO START CONDITION, INSPECTED THE FICM TO MAKE SURE THERE IS NO LOOSE CONNECTION, GOOD, TESTED FOR POWER AND GROUND, FOUND THAT THE PLUG ON THE FICM THAT SUPPLIES POWER TO FUEL INJECTORS 1, 4 ,6 AND 7 IS SUPPLYING NO POWER, FICM HAS SHORTED OUT INTERNALLY AND WILL NEED TO BE REPLACED, INSTALLED NEW FICM AND RETEST, VEHICLE WILL START HOWEVER IT IS RUNNING ROUGH AND MISSING, PERFORMED A CYLINDER CONTRIBUTION TEST AND FOUND THAT THE #4 FUEL INJECTOR IS BAD, RECOMMEND REPLACING THE #4 FUEL INJECTOR AND GLOW PLUG CONTROLLER (NO SUPPLYING POWER TO THE #4 GLOW PLUG) AND THEN RETESTING, REPLACED THE #4 FUEL INJECTOR AND GLOW PLUG CONTROLLER, REPLACED THE FUEL FILTERS AND RETEST, AT THIS TIME VEHICLE IS STARTING, NO FURTHER ISSUES AT THIS TIME
TOW BILL
GEORGE V. gave our service a 5 star review on 1/11/2020
2011 Ford Pickup
Mileage
98,794
Service Date
12/9/2019
Services Performed
Lubricate and check chassis. Change oil and oil filter. Check air filter and breather filter. Check and top-off all fluid levels and tire pressures. Perform basic safety inspection. Road test vehicle.
REPLACE THE FUEL FILTERS AND DRAIN THE WATER IN FUEL SEPARATOR
BUNKY M. gave our service a 5 star review on 12/27/2019
2019 Ford F-350 Super Duty
Mileage
45,606
Service Date
12/24/2019
Services Performed
INSTALL CAMBER KIT ON THE LEFT FRONT
ROAD TEST VEHICLE. CHECK ALL SUSPENSION AND STEERING PARTS FOR WEAR. CHECK TIRE PRESSURE AND CONDITION. CHECK RIDING HEIGHT. CHECK ALIGNMENT OF ALL FOUR WHEELS. ADJUST CASTER, CAMBER, TOE-IN, AND THRUST ANGLE AS NEEDED ON ALL FOUR WHEELS. CENTER STEERING WHEEL.
ROSS P. gave our service a 5 star review on 12/24/2019
2007 Ford Pickup
Mileage
211,848
Service Date
10/9/2019
Services Performed
REPLACE THE SHIFTER
This inspection and the opinions expressed are exactly that, opinions. Many parts perform perfectly until the moment of failure. Failure may occur suddenly and without warning. The inspector and/or all parties relative to the compilation of this report cannot accept liability for failures, which may occur after the inspection is completed. By accepting this report, the consumer acknowledges that the inspector and/or all parties relative to the compilation of this report, cannot be held responsible for any and all alleged vehicle defects, and further, the consumer releases and holds harmless the inspector and/or all parties relative to the compilation of this report from any and all further claims on this vehicle. No warranty for this vehicle is implied or given by the inspector and/or all parties relative to the compilation of this report.
UPON INSPECTION FOUND THAT THE KEY WILL NOT COME OUT OF THE IGNITION BDUE TO THE FACT THAT THE SHIFTER IS NOT ALL OF THE WAY INTO PARK, DISASSEMBLED THE SHIFTER AND FOUND THAT THE HOUSING IS WARN WITH OTHER COMPONENTS, WILL NEED TO REBUILD THE SHIFTER ASSEMBLY AND RETEST, INSTALLED NEW COMPONENTS, REASSEMBLED AND RETEST, SHIFTER AND IGNITION IS WORKING OK AT THIS TIME
PATRICK C. gave our service a 5 star review on 10/10/2019
2015 Ford F-250 Super Duty
Mileage
99,192
Service Date
9/30/2019
Services Performed
FRONT BRAKE PADS ___40____% REMAIN REAR BRAKE PADS ___5______% REMAIN FRONT ROTORS __RESURFACE____ REAR ROTORS __RESURFACE_____ CALIPERS FRONT _OK___ REAR _OK___ BRAKE FLUID CONDITION __GOOD___ RECOMMEND RESURFACING THE FRONT ROTORS, FRONT BRAKE PADS AT THIS TIME CAN BE REUSED IF THE CUSTOMER CHOOSES, RESURFACE THE REAR ROTORS AND REPLACE THE REAR BRAKE PADS, UPON RESURFACING THE FRONT ROTORS FOUND THAT ONE HAS A VERY LARGE GROOVE ON THE BACK SIDE THAT CAN NOT BE MACHINED OUT, REPLACED THE FRONT BRAKE ROTORS AND PADS
REPLACE THE FAN CLUTCH
REPLACE THE REAR BRAKE PADS AND RESURFACE THE REAR BRAKE ROTORS
RESURFACE THE FRONT BRAKE ROTORS
UPON INSPECTION TEST DROVE THE VEHICLE WITH THE CUSTOMER, CUSTOMER HAD A TRAILER LOADED WITH EQUIPMENT FOR THE TRUCK TO TOW, TEST DROVE THE VEHICLE UP HESPERUS HILL, TRUCK OVERHEATED, PERFORMED ON DEMAND TESTING FOR THE FAN CLUTCH, NO RESPONSE, INSPECTED DURING ON DEMAND TESTING AND FOUND THAT FAN CLUTCH HAS FAILED INTERNALLY AND IS HARDLY TURNING, INSTALLED NEW FAN CLUTCH AND RETEST, FAN CLUTCH IS NOW FUNCTIONING WHEN PERFORMING THE ON DEMAND TESTING, ADVISED THE CUSTOMER THAT HE WILL NEED TO TEST DRIVE THE VEHICLE WITH A LOAD TO VERIFY THAT THERE IS NO OTHER ISSUES WITH THE VEHICLE
MIKE Z. gave our service a 5 star review on 10/1/2019

Ford

We Service and Repair all Ford cars